Targeted measures should be taken for the short-term storage of Weifang diesel engines. The following are key precautions.
1、 Weifang Diesel Engine Fuel System Treatment
Fuel tank management
Oil storage control: Maintain over 80% of the fuel in the tank and reduce air contact.
Strictly prohibit mixing oil: avoid mixing old and new diesel to prevent impurities from settling.
Oil circuit protection, turn off the fuel tank switch to prevent fuel evaporation or accidental leakage. Clean or replace the fuel filter to avoid long-term blockage.
2、 Weifang Diesel Engine Lubrication System Maintenance
Oil inspection
If it has been running continuously for more than 100 hours before storage, it is recommended to replace the oil and filter. When the replacement cycle has not been reached, start the engine and run it without load for 5 minutes to evenly distribute the oil.
Rust prevention measures
Spray a small amount of anti rust mist into the cylinder to protect the internal metal surface.
3、 Weifang Diesel Engine Cooling System Protection
Weifang Diesel Engine Coolant Adjustment
Confirm that the coolant level is within the standard range and add rust inhibitor (according to the instructions). Antifreeze should be used in cold regions, with a freezing point 5 ℃ lower than the local minimum temperature.
Cooling system cleaning
Clean the dust on the surface of the radiator to prevent blockage from affecting heat dissipation. Check the water pipe joints to ensure there is no leakage.
4、 Weifang Diesel Engine Battery Maintenance
Power outage handling
Disconnect the negative (-) connection wire of the battery to prevent parasitic currents from depleting the battery. Recharge once a week with a charger
Battery cleaning
Clean the polar oxide and apply Vaseline for rust prevention.
5、 Weifang Diesel Engine External Protection
Physical Isolation
Cover the engine with waterproof cloth to prevent dust and rainwater from entering. Block and stuff into the exhaust duct to prevent small animals from entering the nest.
security check
Remove flammable materials, close fuel valves, and attach warning labels to prevent accidental activation.
6、 Requirements for Storage Environment of Weifang Diesel Engine
Site selection principle
Dry, cool, ventilated place, away from heat sources and corrosive gases. Avoid direct sunlight and control the temperature between 5-30 ℃.
Regular monitoring
Check once a week for oil leaks, battery condition, and integrity of external coverings. Start the engine and run it without load for 15 minutes every two weeks.
7、 Weifang Diesel Engine Special Operating Condition Handling
High humidity areas: Place desiccant packs in the engine compartment or use a dehumidifier to control the environmental humidity to ≤ 60%.
Rainy season: Wrap key components with plastic film.
By strictly implementing the above measures, the Weifang diesel engine can ensure the normal operation of the unit during use. I hope the above introduction can provide users with reference.
More information on Weifang Diesel Engine:https://hq-power.net/
